Effect of insoluble calcium concentration on rennet coagulation properties of milk.

Rennet-induced gels were made from milk acidified to various pH values or milk at pH 6.0 that had added EDTA. The objective was to examine the effect of removing insoluble Ca (INS Ca) from casein micelles (CM) on rennet gelation properties. For the pH trial, diluted lactic acid was added to reconstituted skim milk to decrease the pH to 6.4, 6.0, 5.8, 5.6, and 5.4. For the EDTA trial, EDTA was slowly added (0, 2, 4, and 6 mM) to reconstituted skim milk, and the final pH values were subsequently adjusted to pH 6.0. Dynamic low amplitude oscillatory rheology was used to monitor gel development. The Ca content of CM and rennet wheys made from these milks was measured using inductively coupled plasma spectroscopy. The INS Ca content of milk was altered by the acidification pH values or level of EDTA added. In all samples, the storage modulus (G' ) exhibited a maximum (GM), with a decrease in G' during longer aging times. Gels made at pH 6.4 had higher GM compared with gels made at pH 6.7 probably due to the reduction in electrostatic repulsion, whereas the INS Ca content only slightly decreased. The highest GM value of gels was observed at pH 6.4 and the GM value decreased with decreasing pH from 6.4 to 5.4. This was due to an excessive loss of INS Ca from CM. There was a decrease in GM with the increase in the concentration of added EDTA, which was probably due to the loss of colloidal calcium phosphate, which weakens the integrity of CM. Loss tangent (LT) values at GM increased with a reduction in milk pH and the addition of EDTA to milk. Rennet gels at the point of the GM were subjected to constant low shearing to fracture the gels. With a reduction in INS Ca content, the yield stress decreased, whereas LT values increased indicating a weaker, more flexible casein network. Microstructure of rennet-induced gels near the GM point and 2 to 10 h after this point was studied using fluorescence microscopy. At GM, gels made from milk acidified to pH 6.4 exhibited more branched, interconnected networks, whereas strands and clusters became larger with a reduction in milk pH to 5.4. Gels made from milk with EDTA added had more finely dispersed protein clusters compared with gels made from milk with no EDTA added. These microscopic observations supported the effect of loss of INS Ca on GM and LT. There was a decrease in apparent interconnectivity between strands in gel microstructure during aging, which agreed with the decrease in G' after GM. It can be concluded that low levels of solubilization of INS Ca and the decrease in milk pH resulted in an increase in GM. With greater losses of INS Ca there was excessive reduction in cross-linking within CM, which resulted in weaker, more flexible rennet gels. This complex behavior cannot be explained by adhesive hard sphere models for CM or rennet gels made from these CM.