Gas Processing Center, College of Engineering, Qatar University, P.O. Box 2713, Doha, Qatar.
Chemical Engineering Department, College of Engineering, Qatar University, P.O. Box 2713, Doha, Qatar.
Sci Rep. 2021 Feb 26;11(1):4796. doi: 10.1038/s41598-021-84195-9.
Pyrite scale formation is a critical problem in the hydrocarbon production industry; it affects the flow of hydrocarbon within the reservoir and the surface facilities. Treatments with inorganic acids, such as HCl, results in generation toxic hydrogen sulfide, high corrosion rates, and low dissolving power. In this work, the dissolution of pyrite scale is enhanced by the introduction of electrical current to aid the chemical dissolution. The electrolytes used in this study are chemical formulations mainly composed of diethylenetriamine-pentaacetic acid-potassium (DTPAK) with potassium carbonate; diethylenetriamine pentaacetic acid sodium-based (DTPANa), and L-glutamic acid-N, N-diacetic acid (GLDA). DTPA and GLDA have shown some ability to dissolve iron sulfide without generating hydrogen sulfide. The effect of these chemical formulations, disc rotational rate and current density on the electro-assisted dissolution of pyrite are investigated using Galvanostatic experiments at room temperature. The total iron dissolved of pyrite using the electrochemical process is more than 400 times higher than the chemical dissolution using the same chelating agent-based formulation and under the same conditions. The dissolution rate increased by 12-folds with the increase of current density from 5 to 50 mA/cm. Acid and neutral formulations had better dissolution capacities than basic ones. In addition, doubling the rotational rate did not yield a significant increase in electro-assisted pyrite scale dissolution. XPS analysis confirmed the electrochemical dissolution is mainly due to oxidation of Fe on pyrite surface lattice to Fe. The results obtained in this study suggest that electro-assisted dissolution is a promising technique for scale removal.
黄铁矿垢的形成是烃类生产行业中的一个关键问题;它会影响储层内烃类的流动和地面设备。采用无机酸(如 HCl)处理会产生有毒的硫化氢、高腐蚀速率和低溶解能力。在这项工作中,通过引入电流来辅助化学溶解来增强黄铁矿垢的溶解。本研究中使用的电解液主要由二乙烯三胺五乙酸钾-钾(DTPAK)与碳酸钾、二乙烯三胺五乙酸钠(DTPANa)和 L-谷氨酸-N,N-二乙酸(GLDA)组成的化学配方。DTPA 和 GLDA 已显示出在不产生硫化氢的情况下溶解硫化亚铁的能力。通过在室温下进行恒电流实验,研究了这些化学配方、圆盘旋转速度和电流密度对电辅助黄铁矿溶解的影响。使用电化学工艺溶解的总铁量比使用相同的基于螯合剂的配方和相同条件下的化学溶解高 400 多倍。电流密度从 5 增加到 50 mA/cm 时,溶解速率增加了 12 倍。酸和中性配方的溶解能力优于碱性配方。此外,将旋转速度提高一倍并不会显著增加电辅助黄铁矿垢的溶解。XPS 分析证实电化学溶解主要是由于黄铁矿表面晶格上的 Fe 氧化为 Fe。本研究的结果表明,电辅助溶解是一种很有前途的除垢技术。