Dynamic in vitro calcification of bioprosthetic porcine valves: evidence of apatite crystallization.

OBJECTIVE

Calcification is the most important cause of structural deterioration of glutaraldehyde-fixed bioprosthetic valves. Devitalization of tissue favors calcium deposits in the shape of apatite crystals. Host factors influence the extent and progression of calcification, but the phenomenon can also occur in vitro in the absence of a viable milieu. Whether calcific deposits obtained in vitro are similar to those found in vivo is unknown.

METHODS

Four porcine frame-mounted bioprostheses (St Jude Medical Bioimplant; St Jude Medical, Inc, St Paul, Minn) were tested in vitro by using a pulsatile accelerated calcification testing device at a frequency of 300 cycles per minute at 37 degrees C for 19 x 10(6) cycles with a rapid synthetic calcification solution (final product [calcium x phosphate], 130 mg/dL(2)). Three of the same type of xenografts explanted from human subjects because of calcific failure (time in place, 108 +/- 25.63 mo) served as control grafts. Each sample underwent gross and x-ray examination, histology, transmission and scanning electron microscopy, atomic absorption spectroscopy, electron microprobe analysis, and x-ray powder diffraction methods.

RESULTS

All in vitro bioprostheses were heavily calcific, with intrinsic Von Kossa stain-positive deposits and a mean calcium content of 205.285 +/- 64.87 mg/g dry weight. At transmission electron microscopy, nuclei of calcification involved mostly collagen fibers and interfibrillar spaces and, more rarely, cell debris and nuclei. Electron microprobe analysis showed a Ca/P atoms ratio of 4.5:3, a value intermediate between hydroxyapatite and its precursor, octacalciumphosphate. X-ray powder diffraction showed a well-separated and sharp peak, which is typical of hydroxyapatite. Aggregates of plate-like crystals up to 8 microm in size were observed at scanning electron microscopy, with a typical tabular hexagonal shape consistent with apatite. The morphologic and chemical findings in human explants were similar.

CONCLUSIONS

Intrinsic calcification of glutaraldehyde-fixed porcine valves was induced in vitro. Electron microprobe analysis and x-ray powder diffraction findings were in keeping with apatite crystallization, such as that occurring in valve xenografts implanted in vivo. The model may be of value to accelerate the screening of anticalcific agents and may reduce the need for animal experiments.