This study evaluated pre- to postweaning ruminal structural development, fermentation characteristics, and acute-phase protein levels in calves with a high milk replacer (MR) feeding rate prior to weaning. Six ruminally cannulated Holstein bull calves were fed MR (150 g/L) at 15% of body weight (BW) in 2 equal volumes daily. Volumes were adjusted weekly based on BW. Calves were weaned using a 1-step weaning method, with MR decreased by 50% at the end of wk 5 and full weaning at the end of wk 6. Calf starter, chopped straw, and water were offered ad libitum. Intake was recorded daily, and BW was recorded weekly. From wk 5 to 12, ruminal pH was continuously measured using a ruminal pH bolus. Ruminal fluid was collected weekly from wk 5 to 12 for measurement of short-chain fatty acid concentrations and quantification of total bacteria and protozoa. Rumen papillae were obtained at wk 5, 6, 7, 8, and 12 for histological analysis. Serum amyloid A and lipopolysaccharide-binding protein were measured weekly. Data were analyzed using GLIMMIX procedure of SAS (SAS Institute Inc., Cary, NC), with week as a fixed effect and calf as a random effect. During the weaning step-down, starter intake was 3-fold higher and continued to increase until wk 12. Body weight increased from birth to wk 12; however, BW did not change during wk 6, 7, and 8, possibly due to low metabolizable energy intake caused by the weaning strategy. Preweaning ruminal pH was below 5.8 for approximately 936.3 ± 125.99 min/d, implying ruminal acidosis. Furthermore, ruminal pH below 5.8 reached a peak at wk 8 with 1,203.9 ± 227.65 min/d below pH 5.8 and slowly decreased to 388.1 ± 189.82 min/d below pH 5.8 at wk 12. Papillae surface area, length, and width increased during wk 12 compared with wk 5. Corneum thickness increased by week, whereas spinosum/basale thickness only increased during wk 8 compared with wk 5. The acute-phase protein concentration was highest at wk 1 and then decreased and remained constant until wk 12. In conclusion, even before step-down weaning, calves experienced ruminal acidosis despite low starter intake. Further, the observed prolonged ruminal pH depression suggests that dietary rumen adaptation after weaning can take several weeks in calves with a high MR feeding rate preweaning. The prolonged depressed ruminal pH did not affect acute-phase proteins and this finding, along with the other results, suggests that rumen epithelium barrier integrity is not compromised during weaning.