Reduction of Fusarium proliferatum growth and fumonisin accumulation by ZnO nanoparticles both on a maize based medium and irradiated maize grains.

This study evaluated the antifungal effect of ZnO nanoparticles (ZnO-NPs) on Fusarium proliferatum growth and fumonisin accumulation both on a maize-based medium (in vitro) and on irradiated maize grains (in situ). The ZnO-NPs were obtained by drop-by-drop synthesis without further thermal treatment and characterized by scanning electronic microscopy/ energy dispersive X-ray spectroscopy (SEM/EDS) and X-ray diffraction (XRD). SEM analysis showed them as thin flakes of 200 × 200 nm, ~30 nm thickness and its purity were confirmed by XRD. During the in vitro assay ZnO-NPs (0, 0.8; 4, 8 g L) were evaluated at 25 °C during 21 days under darkness or photoperiod incubation (12/12 h light (cold white and black fluorescent lamps)/darkness) to determine its possible photocatalytic influence. Fumonisins were detected by high performance liquid chromatography coupled to mass spectrometry (HPLC- MS/MS). All ZnO-NPs concentrations significantly affected growth rates and FB accumulation by F. proliferatum RCFP 5033 (p < 0.05). Similar reduction of growth and FB (%) was observed at 0.8 and 8 g L ZnO-NPs under photoperiod or darkness incubation. FB reduction was observed after 14 and 21 days, although the highest reduction occurred after 14 days under photoperiod incubation (84-98%). No clear light enhancing effect on the antifungal and anti-mycotoxin capability of the ZnO-NPs was observed. Morphological alterations in mycelia and conidia were observed by SEM. Under the in situ assay, the effect of the ZnO-NPs (0, 0.4, 0.8, 2 g kg) on growth rates and fumonisin B, B and B accumulation by two F. proliferatum strains was evaluated on irradiated maize grains adjusted to 0.995, 0.98 and 0.97 a in darkness at 25 °C during 21 days. Also, zinc acetate at 0.8 g kg was included to compare their antifungal effect against the same ZnO-NPs concentration. Growth rates decreased significantly as ZnO-NPs concentrations increased. Higher than 60% of growth reduction was observed for both F. proliferatum strains. Zinc acetate significantly reduced growth, although it was less efficient that the same ZnO-NPs concentration. ZnO-NPs reduced total fumonisins accumulation by 71-99% at 0.8-2 g kg ZnO-NPs and 0.98-0.995 a. Moreover, 0.4 g kg ZnO-NPs also produced significant reduction of the 3 fumonisins. This study showed the application of ZnO-NPs in maize grains could be a low cost and environmental impact strategy to control phytopathogen and toxigenic fungi such as F. proliferatum and to reduce fumonisins accumulation, both during crop development at preharvest stage and during maize storage.