Treatment of faecal sludge and sewage effluent by pinewood biochar to reduce wastewater bacteria and inorganic contaminants leaching.

Biochar is a valuable treatment option for faecal sludge management (FSM). However, the sanitation application rates of biochar in FSM are not well established. There is also a gap in knowledge about the effect of actual raw sewage effluent and sludge on organic and inorganic contaminants migration of biochar treated soil. This study investigated the concentration and migration rates of N, P, E. coli and faecal coliform bacteria through different soil-bed biochar column treatments leached with raw faecal sludge and sewage effluent. Forty-four soil-bed leaching columns with pinewood biochar rates at 5, 10 and 20 t/ha were set at the Bloemspruit wastewater plant, South Africa. The pinewood biochar used had a pH of 10.21, total C composition of 92%, surface area of 517 m²/g, and a pore size of 1.7 nm. It was found that the 20 t biochar per ha treatment with faecal sludge increased water retention (flows of 33 mm/h. at 0 t/ha compared to 0.8 mm/h. at 20 t/ha) and leachates purification. High detections were observed for faecal coliforms and E.coli above 4331 CFU/100 mL from the effluent and faecal sludge in soils without biochar. Detection of E.coli at 20 t/ha decreased to 1 CFU/100 mL while the faecal coliforms still had counts above 10 CFU/ 100 mL. The results showed a decreasing rate of nitrates, phosphates, zinc and copper with an increasing biochar application rate. Pinewood biochar showed significant removal efficiencies of bacteria (between 89 and 98%) and nitrates and phosphates (between 68 and 98%). Significant differences were seen at P < 0.05 between the means of the treatments with and without biochar. The results from the study show that pinewood biochar applied at rates between 5 and 20 t/ha has a high organic and inorganic contaminants reduction potential for FSM.