Ang Wui Seng, Elimelech Menachem
Department of Chemical Engineering, Environmental Engineering Program, Yale University, P.O. Box 208286, New Haven, CT 06520-8286, USA.
Water Res. 2008 Oct;42(16):4393-403. doi: 10.1016/j.watres.2008.07.032. Epub 2008 Aug 3.
Effluent organic matter (EfOM) contributes significantly to organic fouling of reverse osmosis (RO) membranes in advanced wastewater reclamation. In this study, the effect of feed solution chemistry (solution pH and Ca(2+) concentration) on the fouling of RO membranes by octanoic acid-selected to represent fatty acids in EfOM-is investigated. Crossflow fouling experiments demonstrate that RO membrane fouling is much more significant at solution pH below the pK(a) of the octanoic acid (pK(a)=4.9) than at an elevated pH. Octanoic acid permeates across the membranes more readily at solution pH below its pK(a) than at elevated pH. At pH below the octanoic acid pK(a), fouling behavior is not affected by calcium ions, whereas at elevated pH, the rate of flux decline decreases with higher calcium ion concentration. The effect of calcium on the fouling behavior was further verified from foulant-foulant adhesion forces, determined by atomic force microscopy (AFM) force measurements under solution chemistries identical to those of the crossflow fouling experiments. To investigate the implications of octanoic acid fouling for wastewater reclamation, the effect of octanoic acid on membrane fouling by a combination of organic foulants in the presence of calcium ions is studied. At a solution chemistry simulating that of typical wastewater effluents, the addition of octanoic acid to a feed solution containing alginate, bovine serum albumin, and Suwannee River natural organic matter, does not enhance membrane fouling behavior. This observation could be attributed to the significant contribution of the alginate-calcium complexes within the fouling layer to the total membrane resistance.
在深度废水再生过程中,出水有机物(EfOM)对反渗透(RO)膜的有机污染有显著影响。本研究考察了进料溶液化学性质(溶液pH值和Ca(2+)浓度)对以辛酸(选为代表EfOM中的脂肪酸)造成的RO膜污染的影响。错流污染实验表明,在溶液pH值低于辛酸的pK(a)(pK(a)=4.9)时,RO膜污染比在较高pH值时更为显著。在溶液pH值低于其pK(a)时,辛酸比在较高pH值时更容易透过膜。在pH值低于辛酸pK(a)时,污染行为不受钙离子影响,而在较高pH值时,通量下降速率随钙离子浓度升高而降低。通过在与错流污染实验相同的溶液化学条件下进行原子力显微镜(AFM)力测量确定的污垢-污垢粘附力,进一步验证了钙对污染行为的影响。为了研究辛酸污染对废水再生的影响,研究了在存在钙离子的情况下,辛酸对由多种有机污垢组合造成的膜污染的影响。在模拟典型废水流出液的溶液化学条件下,向含有藻酸盐、牛血清白蛋白和苏万尼河天然有机物的进料溶液中添加辛酸,并不会增强膜污染行为。这一观察结果可归因于污垢层中藻酸盐-钙络合物对总膜阻力的显著贡献。