Feng Xiao, Cao Xiaowei, Li Lianghao, Li Zhiming, Zhang Qingsong, Sun Wen, Hou Benao, Liu Chi, Shi Zhenzhong
School of Transportation Engineering, Shandong Jianzhu University, Jinan 250101, China.
Xuzhou Metro Group Co., Ltd., Xuzhou 221000, China.
Materials (Basel). 2024 Nov 15;17(22):5597. doi: 10.3390/ma17225597.
Superfine cement is widely used in building reinforcement and repair, special concrete manufacturing, and environmental protection engineering due to its high toughness, high durability, good bonding strength, and environmental friendliness. However, there are some problems in superfine cement slurry, such as high bleeding rate, prolonged setting time, and consolidated body volume retraction. In this article, on the premise of using the excellent injectability of superfine cement slurry, the fluidity, setting time, reinforcement strength, and volume expansion rate of novel expansive superfine cement slurries with varying proportions were analyzed by adding expansion agent UEA, naphthalene-based water reducer FDN-C, and triisopropanolamine accelerating agent TIPA. The results show that under most mix ratios, the bleeding rate and fluidity of the novel superfine cement slurry initially increase and decrease with rising water-reducing agent dosage. The initial setting time generally decreases with accelerating agent dosage, reaching a minimum value of 506 min, representing a 33.68% reduction compared to the benchmark group (traditional superfine cement). Under normal conditions, the compressive strength of the net slurry consolidation body is positively correlated with expansion agent dosage, achieving maximum strengths of 8.11 MPa at three days and 6.93 MPa at 28 days; these values are respectively higher by 6.7 MPa and 2.6 MPa compared to those in the benchmark group. On the seventh day, the volume expansion rate of the traditional superfine cement solidified sand body ranges from -0.19% to -0.1%, while that for the corresponding body formed from the novel superfine cement is between 0.41% and 1.33%, representing a difference of 0.6-1.43%. After the on-site treatment of water and sand-gushing strata, the core monitor rate of the inspection hole exceeds 70%. The permeability coefficient of the stratum decreases to a range between 1.47 × 10 and 8.14 × 10 cm/s, resulting in nearly a thousandfold increase in stratum impermeability compared to its original state. Hence, the findings of this research hold practical importance for the future application of such materials in the development of stratum reinforcement or building repair.
超细水泥因其高韧性、高耐久性、良好的粘结强度和环境友好性,被广泛应用于建筑加固与修复、特种混凝土制造及环保工程中。然而,超细水泥浆存在一些问题,如泌水率高、凝结时间长和固结体体积收缩。本文在利用超细水泥浆优良可注性的前提下,通过添加膨胀剂UEA、萘系减水剂FDN - C和三异丙醇胺促凝剂TIPA,分析了不同配比的新型膨胀超细水泥浆的流动性、凝结时间、增强强度和体积膨胀率。结果表明,在大多数配合比下,新型超细水泥浆的泌水率和流动性最初随减水剂用量的增加而增大,随后减小。初凝时间一般随促凝剂用量的增加而缩短,最短可达506分钟,比基准组(传统超细水泥)缩短了33.68%。在正常条件下,净浆固结体的抗压强度与膨胀剂用量呈正相关,3天抗压强度最高可达8.11MPa,28天抗压强度最高可达6.93MPa;与基准组相比,分别高出6.7MPa和2.6MPa。在第7天,传统超细水泥固化砂体的体积膨胀率在-0.19%至-0.1%之间,而新型超细水泥相应固化体的体积膨胀率在0.41%至1.33%之间,相差0.6 - 1.43%。对涌水涌砂地层进行现场处理后,检查孔的取芯监测率超过70%。地层渗透系数降至1.47×10至8.14×10 cm/s之间,地层防渗性比原来提高了近千倍。因此,本研究结果对于此类材料未来在地层加固或建筑修复开发中的应用具有实际意义。