Filtration through a polyester white cell-reduction filter of plasma-poor platelet concentrates prepared with an acetate-containing additive solution.

It is of practical importance to known whether the adsorption of platelets and contaminating white cells (WBCs) by the WBC-reduction filter is altered when platelet concentrates (PCs) are prepared in a plasma-poor condition with an acetate-containing additive solution (Seto sol). Plasma-poor PCs with 11-percent residual plasma were prepared from apheresis platelet-rich plasma by using a sterile docking device with steam-sterilized Seto sol. Seto sol contains 115 mM (115 mmol/L) NaCl, 4 mM (4 mmol/L) KCl, 3 mM (3 mmol/L) MgCl2, 10 mM (10 mmol/L) Na3PO4, 15 mM (15 mmol/L) acetate, 3 mM (3 mmol/L) Na3 citrate, and 10 mM (10 mmol/L) glucose (pH 7.1). The solution was steam-sterilized under nitrogen gas. On Days 1 and 5, pooled Seto sol PCs (2.4 x 10(11) platelets) were filtered with a polyester filter at a flow rate of 10 mL per minute. The WBC-removal rate was over 99.9 percent with a platelet recovery of 88 percent following Day 1 filtration. These values were very similar to those of plasma PCs, and 84-percent recovery was achieved following Day 5 filtration. However, when 1 unit of Seto sol PCs with half the number of platelets was filtered with the polyester filter, platelet recovery was about 16 to 17 percent less than that of plasma PCs. Platelet quality was maintained if pooled Seto sol PCs were filtered on Day 1 and stored for over 4 days. Filtration did not alter platelet function in 1-day-old or 5-day-old Seto sol PCs.(ABSTRACT TRUNCATED AT 250 WORDS)