Testing the feasibility of using a conveyor belt to load weanling and nursery pigs for transportation.

Transportation is known to be a multi-faceted stressor, with the process of loading being one of the most significant factors impacting the stress to which animals are exposed. This project was designed to determine if using a conveyor to load pigs into the top deck of a simulated straight deck trailer could lower the stress to which pigs and handlers are exposed. Pigs were assigned to either a Control group that were herded up a stationary conveyor ramp into a top deck trailer (2.5 m above the ground); or Conveyor group which were herded onto a mobile conveyor into a top deck trailer. The conveyor was 7.6 m long, 0.9 m wide and rose to 2.5 m high at a 16° slope, and moved 11.3 m/min. Two age groups were tested; Weanling pigs which were moved in groups of 20 ( = 14 groups/treatment) and Nursery pigs which were moved in groups of 10 ( = 15 groups/treatment). Behavior was recorded during loading, including slips and falls, vocalizations, assists, and time to load. Heart rate of 2 sentinel pigs/group and the handler were recorded during loading, and body temperature of the handler after loading. Pigs were held in the simulated trailer for 30 min while heart rate was recorded. After which, they were unloaded and held in a holding pen for an additional 30 min while heart rate was recorded. There were no treatment differences for slips or falls ( < 0.90). Vocalizations were too few to analyze. Both Weanling (2.8 ± 0.7) and Nursery (1.6 ± 0.5) Conveyor pigs needed to be assisted onto the conveyor more than Weanling (1.2 ± 0.4) and Nursery (0.3 ± 0.1) Control pigs ( < 0.06). There was no difference in total loading time between the treatments for any age group ( < 0.15), with Weanling and Nursery pigs loading in 50 to 45 s, respectively. There were no treatment differences for heart rate variability measures ( > 0.10). However, loading increased heart rate of Nursery pigs (204.9 ± 5.7 bpm, < 0.005), but not Weanling pigs (172.1 ± 9.0 bpm). Nursery pigs had a greater ratio of low frequency to high frequency power during loading ( < 0.02) compared to other phases of the procedure in both Control and Conveyor groups. Heart rate (93.9 ± 1.9 bpm) and body temperature (31.1 ± 0.3°C, eye temperature) of the handler was not affected by treatment ( < 0.26). Based on behavior and physiology, the pigs had similar experiences in both treatments. This study shows that it is feasible to use a conveyor to load pigs, but it may not be advantageous.